VERSACHEM CORPORATION -- GASKET SEALANT,0051,13009  -- -
<pre>=====================  Product Identification  =====================

Product ID:GASKET SEALANT,0051,13009
MSDS Date:01/21/1998
FSC:NIIN:Submitter:N EN
Status Code:A
=== Responsible Party ===
Company Name:VERSACHEM CORPORATION
Address:6643 42ND TERRACE NORTH
City:WEST PALM BEACH
State:FL
ZIP:33407
Country:US
Info Phone Num:561-845-2425
Emergency Phone Num:800-424-9300 (CHEMTREC)
Chemtrec Ind/Phone:(800)424-9300
CAGE:0FY40
=== Contractor Identification ===
Company Name:VERSACHEM CORPORATION
Address:6643 42ND TERRACE NORTH
Box:City:WEST PALM BEACH
State:FL
ZIP:33407
Country:US
Phone:561-845-2425
CAGE:0FY40

=============  Composition/Information on Ingredients  =============

Ingred Name:SILCIA, CRYSTALLINE-QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
&lt; Wt:1.
Other REC Limits:0.1 MG/M3 (CANADA)
OSHA PEL:see Table Z-3
OSHA STEL:N/K 
ACGIH TLV:0.1 MG/M3
ACGIH STEL:N/K 

Ingred Name:ISOPROPANOL
CAS:67-63-0
RTECS #:NT8050000
Minumum % Wt:10.
Maxumum % Wt:30.
Other REC Limits:400 PPM (CANADA)
OSHA PEL:980 MG/M3;400 PPM
OSHA STEL:N/K 
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NO DATA AVAILABLE.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: MILDLY IRRITATING TO THE
    SKIN. EYES: EYE IRRITANT. CORNEAL DAMAGE MAY OCCUR. INHALATION: MAY
    CAUSE MILD IRRITATION TO THE NOSE, THROAT AND RESPIRATORY TRACT AND
    MAY RESULT IN CENTRAL NERV OUS SYSTEM DEPRESSION. INGESTION:
    IRRITATING TO THE GASTROINTESTINAL TRACT, CAUSING ABDOMINAL PAIN
    AND VOMITING, SOMETIMES BLOODY. INGESTION MAY CAUSE CENTRAL NERVOUS
    SYSTEM DEPRESSION, LOW BLOOD PRES SURE, RAPID HEART BEAT AND LIVER
    DAMAGE. CHRONIC: NO ADVERSE EFFECTS ANTICIPATED FROM AVAILABLE
    INFORMATION. SEE TOXICOLOGICAL SECTION FOR TOXICOLOGY STUDY DATA.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
    MONOGRAPHS, VOLUME 68, 1997: GROUP 1. NTP 8TH ANNUAL REPORT ON
    CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
    HUMAN: LUNG.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:EXISTING EYE, SKIN AND RESPIRATORY
    DISORDERS.

=======================  First Aid Measures  =======================

First Aid:EYES: FLUSH WITH CLEAN WATER FOR AT LEAST 15 MINUTES WHILE
    GENTLY HOLDING EYELIDS OPEN. GET IMMEDIATE MEDICAL ATTENTION. SKIN:
    IMMEDIATELY REMOVE CONTAMINATED CLOTHING AND EXCESS CONTAMINANT.
    FLUSH SK IN WITH WATER. WASH THOROUGHLY WITH SOAP AND WARM WATER.
    CONSULT A PHYSICIAN IF IRRITATION DEVELOPS. INHALATION: REMOVE
    PATIENT TO FRESH AIR. ADMINISTER OXYGEN IF BREATHING IS DIFFICULT.
    GET MEDICAL A TTENTION IF SYMPTOMS PERSIST. INGESTION: GIVE TWO
    GLASSES OF WATER IF PATIENT IS NOT UNCONSCIOUS OR DROWSY; INDUCE
    VOMITING BY GIVING 2 TABLESPOONS SYRUP OF IPECAC. KEEP VICTIM'S
    HEAD BELOW HIPS WHILE  VOMITING. GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point:=11.7C, 53.F
ESTIMATE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
    EQUIPMENT . CLEAR AREA OF UNPROTECTED PERSONNEL. DO NOT ENTER
    CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR. COOL FIRE-EXPOSED
    CONTAINERS WITH WATER S PRAY.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID CLASS IB. CONTAINERS
    EXPOSED TO INTENSE HEAT FROM FIRES COULD RUPTURE FROM VAPOR
    PRESSURE BUILDUP. HAZARDOUS PRODUCTS OF COMBUSTION: CARBON
    MONOXIDE, CARBON DIOXIDE AND OTHER UNKNOWN	ORGANIC COMPOUNDS.

==================  Accidental Release Measures  ==================

Spill Release Procedures:AVOID PERS CONT. ELIM IGNIT SOURCES. VENT
    AREA. DIKE, CONTAIN & ABSORB W/CLAY, SAND/OTHER SUITABLE MATL. WEAR
    APPROP NIOSH APPRVD RESP & PROT CLTHG. FOR LGE SPILLS, PUMP TO
    STOR/SALVAGE VESSELS. SOAK	UP RESIDUE W/ABSORB SUCH AS CLAY,
    SAND/OTHER SUITABLE MATL & DISPOSE OF PROPERLY. FLUSH AREA W/WATER
    TO REMOVE TRACE RESIDUE. SML SPILLS: TAKE UP W/ABSORB MATL & PLACE
    IN APPROP CONTRS FOR (SUP DAT)

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT BREATHE VAPOR OR MIST. DO NOT
    GET IN EYES, ON SKIN OR CLOTHING. CLOSE CONTAINER AFTER EACH USE.
    GROUND CONTAINER WHEN POURING. KEEP AWAY FROM HEAT, FLAME OR
    SPARKS. USE NON-SPARKING TOOLS. KEEP  IN A COOL PLACE, WITHOUT
    DIRECT EXPOSURE TO SUNLIGHT.
Other Precautions:KEEP CONTR TIGHTLY CLOSED & OTHERWISE IN ACCORDANCE
    W/NFPA REGS. MAINTAIN AIR SPARCE IN STOR CONTRS. PROVIDE APPROP
    VENT/NIOSH APPRVD RESP PROT AGAINST DECOMP PRODS DURING
    WELDING/FLAME CUTTING OPERAT IONS & TO PROTECT AGAINST SILICA DUST
    DURING SANDING/GRINDING OF CURED PROD.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE REQUIRED IF AIR CONCENTRATIONS ARE BELOW
    PERMISSIBLE LEVELS. OTHERWISE, A NIOSH APPROVED AIR PURIFYING
    RESPIRATOR WITH AN ORGANIC VAPOR CARTRIDGE MAY BE PERMISSIBLE. USE
    A NIOSH APPROVED POSITIVE  PRESSURE AIR SUPPLIED RESPIRATOR IF
    THERE IS ANY POTENTIAL FOR UNCONTROLLED RELEASE, OR UNKNOWN
    EXPOSURE LEVELS.
Ventilation:USE VENTILATION THAT IS ADEQUATE TO KEEP EMPLOYEE EXPOSURE
    TO AIRBORNE CONCENTRATIONS BELOW EXPOSURE LIMITS.
Protective Gloves:WEAR IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
    SHOWER . WEAR IMPERVIOUS BUTYL RUBBER CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINER
    TIGHTLY CLOSED. OBSERVE LABEL PRECAUTIONS.
Supplemental Safety and Health
SPILL PROC: DISP. PVNT SPILL FROM ENTERING DRAINAGE/SEWER SYS,
    WATERWAYS, & SURF WATERS. USE BONDING/GROUNDING LINES & NON-SPKG
    TOOLS. PHYSICAL/CHEM PROPERTIES: VOC (GRAMS/LITER): N/K; PERCENT
    SOLIDS  BY WT: >60; PH (5% SOLN/SLURRY IN WATER): N/K.

==================  Physical/Chemical Properties  ==================

Boiling Pt:=82.2C, 180.F
Melt/Freeze Pt:=-88.3C, -127.F
Vapor Pres:32 MMHG @ 68F
Vapor Density:2.1(AIR=1)
Spec Gravity:0.8 - 1.5
pH:SEE SUP DAT
Evaporation Rate &amp; Reference:1.4 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, WITH SOLVENT ODOR.
Percent Volatiles by Volume:<40

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
DO NOT USE UNCURED MATERIAL WITH ALUMINUM EQUIPMENT AT TEMPERATURES
    ABOVE 120F. AVOID CONTACT WITH STRONG OXIDIZING AGENTS, ACIDS,
    CHLORINE, ACETALDEHYDE, ETHYLENE OXIDE.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES, TEMPERATURES
    ABOVE 120F AND IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
    UNKNOWN PRODUCTS OF DECOMPOSITION.

===================  Toxicological Information	===================

Toxicological Information:ACUTE ORAL LD50 (RAT)/ACUTE DERMAL LD50
    (RABBIT)/ACUTE INHAL LC50 (RAT)/EYE IRRIT: NO DATA AVAIL.
    SUBCHRONIC EFTS: RAT & MOUSE INHAL TOXICITY: SUBCHRONIC NOAEL WAS
    500 PPM BASED ON CLINICAL SIGNS OF C NS DEPRESS (BOTH SPECIES) &
    INCRD BODYWT & BLOOD EFTS (RAT ONLY) SEEN AT 1500 PPM. CARCIN,
    TERATOGENICITY, & MUTAGENICITY: IN RESPONSE TO TSCA TEST RULE,
    SEVERAL STUDIES OF IPA HAVE NOW BEEN COMPLETED . STUDIES & THEIR
    RSLTS ARE AS FOLLOWS: 1) BOTH MUTAGENICITY STUDIES, MOUSE
    MICRONUCLEUS & CHO ASSAYS, WERE NEG. 2) RAT & RABBIT ORAL
    TERATOGENICITY & DEVEL TOXICOLOGY: A) THERE WAS NO EVIDENCE THAT I
    PA CAUSED TERATOGENICITY (OTHER INFO)

=====================  Ecological Information  =====================

Ecological:ECOTOXICITY: NO DATA AVAILABLE. MOBILITY AND PERSISTENCE: NO
    DATA AVAILABLE. ENVIRONMENTAL FATE: NO DATA AVAILABLE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT WOULD BE A
    HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR 261). DISPOSE OF ACCORDING
    TO APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.

===================  MSDS Transport Information  ===================

Transport Information:PROPER SHIPPING NAME: ISOPROPANOL SOLUTION.
    HAZARD CLASS: 3. UN NUMBER: 1219. PACKING GROUP: II. EMERGENCY
    RESPONSE GUIDE NUMBER: 129. IMDG PAGE NUMBER: 3244.

=====================  Regulatory Information  =====================

SARA Title III Information:FOR PURPOSES OF SARA SECTION 312 HAZ MATLS
    INVENTORY REPORTING, THE FOLLOWING HAZ CLASSES APPLY TO THIS MATL:
    IMMED HLTH HAZ - DELAYED HLTH HAZ - FIRE HAZ. ACCORDING TO APPROP
    REGS FOR EMER PLANNING &  RELEASE REPORTING REQS FOR SUBSTANCES ON
    SARA SECTION 301 EXTREMELY HAZ SUBSTANCE LIST, NO INGS IN THIS MATL
    ARE CONSIDERED EXTREMELY HAZ. NO INGS IN THIS MATL ARE LISTED IN
    SARA SECTION 313 LIST OF  TOX CHEMS, FOR WHICH RELEASE REPORTING
    MAY BE REQUIRED. FOR SPECIFIC REQS, CONSULT APPROP REGS.
Federal Regulatory Information:U.S. FED REGS: TSCA: ALL INGS OF THIS
    PROD ARE LISTED/ARE EXEMPT FROM LISTING, ON TSCA INVENTORY. EXPORT
    NOTIFICATION IS REQUIRED UNDER TSCA SECTION 12B. THE FOLLOWING RCRA
    CODE(S) APPLIES TO THIS MAT L IF IT BECOMES WASTE: D001. REGULATORY
    STATUS OF HAZ CHEM CONSTITUENTS OF THIS PROD: CERCLA RQ (LBS):
    NONE; TSCA 12B EXPORT NOTIFICATION: CRYSTALLINE SILICA: NOT
    REQUIRED; ISOPROPANOL: REQUIRED. CANA DIAN REGS: WHMIS HAZ
    CLASS(ES): B3; D2B. ALL COMPONENTS OF THIS PROD ARE ON THE DOMESTIC
    SUBSTANCES	LIST.
State Regulatory Information:OTHER INFO: OFFSPRING (MAX DOSE 1200 PPM).
    MILD, REVERSIBLE, LIVER EFFECTS HAVE BEEN NOTED WHEN LABORATORY
    ANIMALS HAVE BEEN OVEREXPOSED TO IPA. TOXICOLOGICAL INFORMATION ON
    HAZARDOUS CHEMICAL CONSTIT UENTS OF THIS PRODUCT: CRYSTALLINE
    SILICA: ORAL LD50 (RAT): N/K; DERMAL LD50 (RABBIT): N/K; INHALATION
    LC50  4HR (RAT): N/K. ISOPROPANOL: ORAL LD50 (RAT): 5045 MG/KG;
    DERMAL LD50 (RABBIT): 12.8 G/KG;  INHALATION LC50 4HR (RAT): 22627
    PPM

=======================  Other Information  =======================

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.